My Yogurt Didn't Set. What Can I Do? (2024)

Sneak Preview: If your yogurt didn’t set, here are some ideas for what to do next. Don’t throw your milk out yet!

As an Amazon Associate, I earn from qualifying purchases.

Have you just discovered your yogurt project still looks like milk? So now you’re asking yourself what to do next. Right?

DON’T GIVE UP JUST YET!

Oh, the disappointment and anguish overwasting money on milk, not to mention your time.

I can’t count how often I getdesperate emails seeking to recover and make good yogurt from the same batch of milk or recycle the non-yogurt-milk into something entirely different.

You are not alone!

The answer to these questions can go in several ways. First, if you know why your yogurt failed, you have a good chance of success if you try again with the same batch.

Was your incubation temperature too high or too low? Was your starter too old or dead? Check out my yogurt trouble-shooting postif you aren’t sure.

But what if you don’t know what you did wrong and do everything the same way again? As the old saying goes, you can probably expect the same poor results.

Here are some suggestions based on my own experience:

4 steps to possible yogurt recovery

1.Does the milk smell bad?

If so, throw it out — no need to ask any more questions.

If the milk still smells OK and you aren’t feeding it to anybody who is immunocompromised, such as the very young, the very old, or very ill, then proceed to the next step.

2. It’s unnecessary to reheat the milk.

I assume you heated the milk to 175˚ F the first time around, and then let it cool back to 100-110˚ F. DO NOT reheat a second time to 175˚F.

If your milk has cooled down to room temperature, you can warm it back to 100˚F if desired. BE VERY CAUTIOUS not to let the milk go above 110˚ F. If you accidentally overheat the milk and it separates or clabbers, you’ve just made fresh ricotta cheese. KEEP READING for what to do next if this happens to you.

3. Add a new starter.

If you suspect the original starter was the cause of your failure, try a different starter. Make sure the new starter is fresh and contains no additives.

4. Re-incubate per my original instructions for making yogurt.

Start with the incubation step—no need to reheat the milk to 180˚F.

See the video in this post for instructions for making yogurt from beginning to end if you prefer pictures to words.

Option #2 for failed yogurt that still smells good but looks like milk:

Make fresh ricotta cheese from failed yogurt.

If you are sure you remembered to add “starter,” you could try this idea. I accidentally discovered it when I had a yogurt fail recently.

In step #2 above, I was heating the milk back to 100˚ F in the microwave. But somehow, the milk was warmer than I realized. In no time at all, the milk started boiling (and popping).

Overheating milk that contains a starter will cause it to curdle and separate. Adding the starter changes the pH.

Don’t panic! Here’s what you can do:

Grab a slotted spoon and start dipping out the curds into a cheesecloth or coffee-filter-lined colander. This process will drain most of the whey off. After that, only the curds will be left behind.

Season the ricotta cheese with a pinch of salt, and refrigerate it. Your reward will be fresh ricotta cheese perfect for lasagna or almost any other ricotta recipe. Use it immediately or freeze it for the next time you make lasagna soup.

For more information and pictures of the process, see my post on making ricotta cheese.

Why did my yogurt fail?

1. Did you remember to add the starter?

I’ve had several failures through the years, primarily due to my forgetfulness.

For example, I heatedthree batches of milk (2 quarts each) last night. Then, as usual, I set them on the counter to cool down to approximately 110˚ F.

Later in the evening, I went to bed without thinking about the milk again until I awoke at 6:00 this morning. As I lay in bed, it hit me that I forgot to add the “starter” and put the milkinto the oven to incubate.

Throwing out all that milk was unthinkable. But, it didn’t smell bad, so I heated the milk to 100 degrees, added a little more starter, and incubated as usual. Fivehours later, I had perfect yogurt.

Was your starter fresh? The fresher, the better. When older than ten days, your chances for good yogurt decrease in a hurry.

Is it possible you killed the yogurt because your milk was too hot when you added the starter? Use a thermometer if you aren’t sure.

3. Does your incubation system maintain the correct temperature?

Another scenario I often hear about is forgetting to turn on the heat for your incubation “system.” Again, if the milk still smells OK, reheat the milk mixture to 100˚ F. Turn on your heat source for incubation and givethe milk a few more hours to make yogurt.

If your system doesn’t include a built-in thermostat, you might want to double-check it. For example, is it holding the temperature where it needs throughout the entire incubation period?

4. Is your yogurt too thin?

Perhaps your “fail” could be better described as drinkable yogurt. Then, as long as it smells good, you could try again.

Perhaps it just needs to incubate longer. Keep incubating. Remember that once you stir or jostle the inoculated milk, you will have to start over again with a new starter.

There are many ways to make the yogurt thicker before incubation with additives and techniques. However, the easiest way to make a batch of completed yogurt thicker is to strain it.

Unfortunately, if your yogurt is very thin, it won’t strain very well. Instead, it will pour right through your lined strainer. If this is your situation, try again with more starter.

If you don’t want to re-incubate, I recommend using the yogurt-milk as is, even if it’s not what you originally planned. Try it in smoothies. Substitute it for buttermilkin baked goods such as these cinnamon biscuits. Or make ricotta cheese as described above.

As one of my readers once told me, “The yogurt gods can be fickle.” Whenever you’re dealing with a live organism, the results can be unpredictable.

Please don’t be discouraged.

The more experience you have, the fewer failures you will experience.

What else would you like to read about homemade yogurt?